Complaint volume
78 consumer-submitted complaints are matched to this model year. Treat the count as a research signal, then read the actual summaries for repeated symptoms.
Complaint records
2025 Ford Explorer Complaints
78 consumer-submitted complaints on record for the 2025 Ford Explorer, grouped by component category.
78 Total complaints
6 Crash reports
0 Fire reports
3 Injury reports
Complaint data reflects consumer-submitted reports. A complaint is not proof
of a defect, recall, or manufacturer fault. Enriched severity fields come
from official bulk records when the complaint can be matched by ODI number.
Buyer interpretation
How to use these complaints before buying
Complaint records are most useful when they turn into inspection points, seller questions, and comparison checks against nearby model years.
Pattern to inspect
The most common categories are unknown or other, power train, visibility/wiper. Use those categories as a test-drive checklist instead of judging the vehicle from the total count alone.
Severity flags
Enriched records include 6 crash reports, 0 fire reports, 3 injury reports, and 0 fatality reports. These fields come from complaint records and should be read in context.
Mileage clue
Mileage is available on 12 complaints, with an average reported failure mileage of 3,799 miles. Compare that with the mileage on the listing.
Questions to ask the seller
- Have you had any problems related to unknown or other, power train, visibility/wiper?
- Can I see recent maintenance and repair records?
- Has the vehicle ever been towed, involved in a crash, or repaired for the same issue twice?
- Can we also check the recall record for this 2025 Ford Explorer?
Used-car checklist
Use these complaints before the test drive.
Build a buyer checklist to turn these issues into questions and inspection points.
2025 Ford Explorer
Build buyer checklist Compare with other years Sends year, make, and model to pre-fill your checklist.
How severe are the 2025 Ford Explorer complaints?
6 Crash
0 Fire
3 Injury
0 Fatality
1 Towed
2 Medical attention
What are the most common 2025 Ford Explorer complaint categories?
UNKNOWN OR OTHER 9
POWER TRAIN 8
VISIBILITY/WIPER 5
ELECTRICAL SYSTEM 4
FORWARD COLLISION AVOIDANCE 3
STEERING 3
STRUCTURE 3
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY/WIPER 2
ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE 2
ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE 2
78 total complaints on record
Latest complaints
| Date | Component | Summary | Severity | Mileage |
|---|---|---|---|---|
| Dec 2025 | UNKNOWN OR OTHER,VISIBILITY/WIPER | There is a large black box on the interior windshield surrounding the rearview mirror. This box blocks the defrost on the windshield, causing ice buildup on the windshield in this area thus causing ice buildup on the windshield wipers. This causes the windshield wipers to be ineffective at removing water, snow, slush, - whatever debris is on the windshield from being removed greatly decreasing visibility in freezing temperatures. I first noticed this when it started to get cold and my windshield wipers were making a strange noise. I got out of the car to see what was going on with the windshield and noticed the ice building up at the top middle of the windshield. As I drove, and the temperatures dropped, the top half of my windshield where this black box is iced up causing my windshield wipers to be ineffective on about the top half of my windshield. This greatly reduced visibility in already reduced visibility driving conditions. This was not just ice on the windshield. It was very obviously accumulating where this box is, due to ineffective defrost of the windshield. | Crash: No Fire: No | Unknown |
| Dec 2025 | ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY/WIPER | My vehicle originally showed more than 10 open safety recalls in the FordPass app and at the servicing dealer. I saved screenshots of each recall. After Ford performed a remote over-the-air software update, all but one recall suddenly disappeared from the app even though no physical repairs were done and no documentation was provided. NHTSA still shows Recall 25V543 as incomplete, involving BCM soldering defects that can cause trailer taillamp failure, electrical malfunctions, HVAC issues, mirror/window failures, power outlet issues, and other safety-related electrical problems. The dealer has not scheduled the repair despite parts being listed as available. Ford Motor Company and the dealer have not provided any recall history, OASIS report, repair documentation, or explanation for why multiple recalls disappeared. This creates a safety concern because the vehicle may have unresolved electrical or lighting defects that were not properly repaired or were prematurely marked as closed after a software update. The issue has not been resolved, and Ford has not responded to multiple requests. | Crash: No Fire: No | Unknown |
| Dec 2025 | UNKNOWN OR OTHER,ENGINE | 12 V Battery continues to die and I've had the car less than a year. On [XXX] the battery was dead. Our neighbor put it on his supercharger. On [XXX] the 12V battery low light came on while I was driving 30 miles away. It went off the next day and reappeared on Thursday [XXX] disappeared on Friday and back on Saturday. I called the Future Ford on Monday and technician [XXX] said it only showed 15% charge. I took it in to the dealership and it was kept over night and the next day he said it was charged to 90%. I was not happy with the "you can come and get it". I told him I'm a [XXX] and bought this car so I wouldn't breakdown and now I don't feel safe with it. He checked the charge again while we were on the phone and he said it dropped to 80%. He said thats not good it will probably need a new battery. That evening he text and said it is fully charged and I can come get it without a new battery. I was not happy as I've received no reason for why it was losing charge. So I did some research on my on and text him back that evening. I told him about my research and found this was an ongoing problem and that they need to find out what is causing the draining issue. I'm sure the dealership had to know as there was a recall for this issue. I suggested a Parasitic test, or software glitch issues to check. He said they would run the parasitic test.. He said it would take several days. I checked back on 12/4/25 and he said No Progress today. I told him I want a copy of all the test run. Wouldn't you know it he gets right back to me saying a handful of modules need updated software. That they will attend them this morning. I think they were trying to get out of the fix as my warranty runs out this month. Why are only certain vehicles being recalled (mine not one of them), when they all should be recalled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) | Crash: No Fire: No | Unknown |
| Dec 2025 | STEERING | When making a turn or going around curves the steering does not return to center and sticks in whatever direction you are turning | Crash: No Fire: No | Unknown |
| Dec 2025 | STEERING,POWER TRAIN,FUEL/PROPULSION SYSTEM | I would need to change many more of the points on the top, see report. | Crash: No Fire: No | Unknown |
| Nov 2025 | STEERING | -EPAS malfunctioning and is available for inspection. -Steering sticks in turns and requires too much effort to return to center causing me to overcorrect which causes the steering to stick in the opposite direction and so on. This is not consistent or predictable Also The car is constantly drifting left to right and requires constant corrections to maintain center. -I replicated the issue with the dealer in the car. Dealer said the other car drove the same so there was nothing they could do. -only the dealer has looked at it -no warning lamps present at this time -i have videos that show the car taking turns on a mountain pass and I am able to let go of the wheel and the car continues to turn. Without steering assist features activated. It should at least try to center on its own. | Crash: No Fire: No | Unknown |
| Nov 2025 | STEERING | Steering drifts to left and will not return to center with out darting to the right when correcting , a constant movement back and forth to keep it in your lane ! | Crash: No Fire: No | Unknown |
| Nov 2025 | ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY/WIPER | “I rented vehicle VIN [XXX] from Budget Rental Car in Panama City Beach, FL (Reservation #XXX, Rental Agreement XXX). I later discovered the vehicle had an unrepaired federal safety recall (NHTSA Recall 25V543 / Manufacturer Recall 25C42) involving the Body Control Module. Budget never informed me of the recall at any time. On November 11, 2025, when I attempted to extend my rental, the representative told me the vehicle had been ‘sold’ and must be returned within two days. When I attempted to exchange it on November 12–13 at three different Budget locations in Lansing, MI, they refused to take the vehicle, stating it had a safety recall and should not have been rented out. Only after this did I check the VIN myself and learn of the safety recall. The recall affects multiple electrical and visibility-related components: trailer lights, interior lights, mirrors, windows, rear defroster, USB/12V ports, and HVAC systems. These issues can reduce driver visibility and increase the risk of a crash. While driving the vehicle, I experienced visibility problems. The windows fogged up severely, and the defroster did not operate properly. As a result, I was unable to see an animal that entered the roadway and unfortunately struck it. There is now damage to the front driver’s side of the vehicle. This visibility impairment aligns with the Body Control Module recall defects described by NHTSA. This vehicle should not have been rented to any customer, especially with the remedy unavailable until late 2025. I am reporting this because an unrepaired safety recall vehicle placed into active rental service directly resulted in a visibility hazard and an unavoidable collision while I was driving.” I did not make it back in time to return the vehicle yesterday 11/14/2025 I am finishing up this report and on my way to Budget in Panama City Beach Florida to return it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) | Crash: No Fire: No | Unknown |
| Nov 2025 | UNKNOWN OR OTHER | Ever since the last recall got resolved the car has failed to go into the gear it’s set to. Such as it fails to go in park when you shift it into park. This is a serious issue as I have now almost rear ended cars in parking lots a few times because of this issue. | Crash: No Fire: No | Unknown |
| Nov 2025 | VEHICLE SPEED CONTROL | See Attached Repair Order | Crash: No Fire: No | Unknown |
| Oct 2025 | POWER TRAIN | Stopped at traffic light when changed to green pushed on the gas started to roll backwards . Got it stopped and pushed on gas would barely go sounded like transmission slipping. Finally got it thru the stoplight and it started again. Got it home called local dealership took it in and have to take it back Friday morning at 8. Scary! | Crash: No Fire: No | Unknown |
| Oct 2025 | VEHICLE SPEED CONTROL,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE | Three times in 5 months since purchasing our 2025 Ford Explorer, all dash lights will come on while driving and vehicle will come to a stop. Braking pressure is reduced greatly and then vehicle will not continue in forward or reverse. Multiple restart attempts will allow the vehicle to move under 5 MPH but will brake hard to a stop if it goes over 5MPH. Two different dealerships have inspected and preformed the same software updates Ford is recommending and its not fixing the issue. Ford is refusing to do anything about it at this time because they claim the software update is as far as they are allowed to go in diagnoses. I have a Ford Case #XXX | Crash: No Fire: No | Unknown |
| Oct 2025 | POWER TRAIN,ENGINE | My 2025 Ford Explorer ST-Line is up to date on recalls as of October 7, 2025. However, I am still experiencing engine "shudder" and hesitation at low RPMs (between idle and 1500 RPM) when accelerating. The 10 speed transmission is also continuing to shift harshly at times. I am very concerned that the hesitation and shudder could be an issue when pulling out into traffic. By comparison, my previous 2017 Explorer did not exhibit this behavior, whichh I consider disconcerting. Also, this car (and all 2025 Explorer models ) injects Fake Engine Noise into the audio speakers to make the 2.5L engine sound more powerful. These fake "bass tones" are disturbing to some passengers with hearing aides, and per Ford's website there is no way to disable the fake noise. Thus, some people with a hearing disability cannot ride in my car without removing their hearing aides. It should be unacceptable to not be able to disable that feature. Note updated form dated 8/1/25 states Fake Noise cannot be turned off. | Crash: No Fire: No | Unknown |
| Oct 2025 | WHEELS,UNKNOWN OR OTHER | The carpet on the wheel wells is not functional. We live out on a ranch on a dirt road and when it rains the mud gets stuck on the carpet and weighs is down. This can cause more damage to the vehicle. We took it in to a dealership and they said there was nothing they could do until the carpet gets ripped off. When we bought an expensive 4x4 vehicle we expected it to be sturdy enough to not have to worry about mud (especially when the car has a built in mud feature). | Crash: No Fire: No | Unknown |
| Oct 2025 | ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE | While traveling down the road - not turning or braking - several alerts and alarms started flashing on the driver dashboard on my 2025 Explorer. At this time, I completely lost the ability to slow the car down. The digital emergency brake made no changes to the braking ability. I was able to eventually able to get the vehicle to slow down by engine torquing and turning. I reached out to my local dealership where I purchased the vehicle, and they told me to call Ford Roadside Assistance immediately. They contracted a local towing agency, and they promptly towed the vehicle to that dealership. I was able to take a movie of the incident. | Crash: No Fire: No | Unknown |
| Oct 2025 | VISIBILITY/WIPER | Driving to park in garage and camera system came on the display screen, non-functional, displaying a black screen and message with "There's an issue with your camera system" - please see dealer for service. *This has happened twice, once on [XXX] at 9pm and a 2nd time [XXX] at 840pm. So far, as of writing this on 10/2 it has not repeated. Took car to dealership to inspect and codes were evident in system. Dealership investigating (10/2/25 at 1004 AM) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) | Crash: No Fire: No | Unknown |
| Sep 2025 | VISIBILITY/WIPER | Bought my new 2025 explorer an 2 days laterits been parked I noticed a craked on the windshield there is no rock ship nor nothing hit it but i did notice theres 2 cracks on the top black part of windshield where it just out of nowhere keeps cracking down took it to safelite an they said thats a Defect on the windshield | Crash: No Fire: No | Unknown |
| Sep 2025 | UNKNOWN OR OTHER | The expansive and overly complicated electronic display has moving menu buttons. By that I mean when you use a feature such as the heated seats or radio source and make a choice, the next time you go there to change something the buttons are in a different order with the previous choice showing first. The radio source actually moves the entire menu to another part of the screen. You have to take your attention off the road for far too long to find what you are looking for. The 2025 Explorer has a very dangerous electronic display that requires far too much attention. As stated, some buttons change location, others are too small to see. The cruise control display is minuscule and mixed in with other display components when there is far more than enough unused space on the screen for larger graphics. I'm sure Ford will use the excuse to use voice controls, but the system is slow and gets it wrong half of the time. In my opinion Ford should be forced to change all of this and send software updates to all affected vehicles. | Crash: No Fire: No | Unknown |
| Sep 2025 | POWER TRAIN | Automatic Return To Park safety feature failed to stop vehicle from forward rolling causing vehicle to crash into open garage. The drivers door hit side of garage frame, closing onto my left leg causing calf muscle pain and bruising. | Crash: Yes Fire: No Injuries: 1 Medical attention | Unknown |
| Sep 2025 | ELECTRICAL SYSTEM | The contact owns a 2025 Ford Explorer. The contact stated that while driving at undisclosed speeds on several occasions with the cruise control activated, the vehicle inadvertently accelerated to 70 MPH. The contact stated that the unintended acceleration had occurred on Highway 70, even though the Speed Limit was 25 MPH. The contact stated that the incorrect Speed Limit was displayed on the instrument cluster. The contact became afraid of driving the vehicle because the failure could be potentially harmful. The vehicle was taken to a dealer; however, the failure was not duplicated. The manufacturer was not notified of the failure. The failure mileage was approximately 25. | Crash: No Fire: No | 25 |
| Aug 2025 | STEERING,SERVICE BRAKES | On October 24, 2024, my 2025 Ford Explorer ST experienced a sudden steering column lock and complete loss of braking while I was driving, leading to a crash and injuries. The vehicle had approximately 800 miles and was a warranty replacement provided weeks earlier. Prior to delivery, the dealer referenced a Quality Assurance hold of about two months on this vehicle, which was not disclosed to me in any detail. The simultaneous loss of steering and brakes suggests a potential common cause safety defect that may affect other 2025 Explorer ST vehicles. My insurer State Farm is currently conducting a Cause and Origin inspection. I request NHTSA review for a potential defect trend. | Crash: Yes Fire: No Injuries: 1 Towed Medical attention | Unknown |
| Aug 2025 | POWER TRAIN,ELECTRICAL SYSTEM,AIR BAGS | As ZERO Recall data refreshed on Aug 09,2025 shows Unrepaired Recalls associated with 2025 Explorer. Please BROADCAST...THE FOLLOWING.. 2025 Explorer Safety Recalls* Missing o-ring supporting disc on bosch fuel injectors Recall incomplete Accessory protocol interface module software update - loss of rear-view camera image Recall incomplete Missing dashboard air bag warning label Recall incomplete Transmission cross member bolt torque Recall incomplete Powertrain control module pcm reprogram Recall incomplete Front subframe bolt torque check Recall incomplete Front brake caliper bolt inspection Recall incomplete Unrequested second-row seat movement Recall incomplete Transmission main control valve body replacement Recall incomplete Connecting rod inspection Recall incomplete While the investor is being held up by the DEPARTMENT OF THE TREASURY, he is awaiting in Ogden, UT for the release of funding to help fix this list of reported RECALL and alerts. By providing engineers with the held and pending release of notes/bills being paused without explanation by the INTERNAL REVENUE SERVICE. As the close of stock options supports the claim for legitimate use and collect my MECCA EXPRESS INC TR, as trustee for collecting funding for these issues. Please BROADCAST..... and advise owners of this vehicle type to stop driving them ASAP as Powertrain control module pcm reprogram, and Missing o-ring supporting disc on bosch fuel injectors. May cause engine failure at HIGH MPH during high RPM on highway and road ways. Potential stall is possible, PLEASE REPORT ASAP. For safety international! | Crash: No Fire: No | Unknown |
| Aug 2025 | POWER TRAIN,ELECTRICAL SYSTEM,AIR BAGS | VIN: [XXX] Recall data refreshed on Aug 09,2025 0 Unrepaired Recalls associated with this VIN for 2025 Police Interceptor - Utility While the 2025 Ford Explorer is recalled,this model for 2025 Police Interceptor - Utility has additional incomplete issues to be reported by NHTSA. As officers on duty should turn these models in to the nearest Ford dealer for competition of the following: 2025 Police Interceptor - Utility Safety Recalls* Missing o-ring supporting disc on bosch fuel injectors Recall incomplete Accessory protocol interface module software update - loss of rear-view camera image Recall incomplete Missing dashboard air bag warning label Recall incomplete Transmission cross member bolt torque Recall incomplete Powertrain control module pcm reprogram Recall incomplete Front subframe bolt torque check Recall incomplete Front brake caliper bolt inspection Recall incomplete Unrequested second-row seat movement Recall incomplete Transmission main control valve body replacement Recall incomplete Connecting rod inspection Recall incomplete This RECALL is a IMMEDIATE Report for any on duty peace officer assigned to these vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) | Crash: No Fire: No | Unknown |
| Aug 2025 | UNKNOWN OR OTHER | Instrument panel and center dash monitor: Multiple times, one and/or both have had a blacked out screen during power up and after engine start. The screens never come on or they go dark after powering up the vehicle. Safety concerns: This limits the HVAC system control during hot summer months in TX. The back up camera is not available. Navigation is lost. The Explorer is at the dealer now undergoing diagnostic testing. | Crash: No Fire: No | Unknown |
| Jul 2025 | VISIBILITY,STRUCTURE | The contact owns a 2025 Ford Explorer. The contact stated while driving 65 MPH, there was an abnormal windy sound coming from the driver's side-view mirror. The vehicle was taken to two different dealers, where it was determined that the turbulence was caused by the mirror. The contact was informed that the molding was different from the passenger's side-view mirror molding. The dealer determined that driver's side-view mirror needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 15,000. | Crash: No Fire: No | 15,000 |