Complaint volume
345 consumer-submitted complaints are matched to this model year. Treat the count as a research signal, then read the actual summaries for repeated symptoms.
Complaint records
2022 Ford Bronco Complaints
345 consumer-submitted complaints on record for the 2022 Ford Bronco, grouped by component category.
345 Total complaints
6 Crash reports
2 Fire reports
3 Injury reports
Complaint data reflects consumer-submitted reports. A complaint is not proof
of a defect, recall, or manufacturer fault. Enriched severity fields come
from official bulk records when the complaint can be matched by ODI number.
Buyer interpretation
How to use these complaints before buying
Complaint records are most useful when they turn into inspection points, seller questions, and comparison checks against nearby model years.
Pattern to inspect
The most common categories are visibility/wiper, service brakes, unknown or other. Use those categories as a test-drive checklist instead of judging the vehicle from the total count alone.
Severity flags
Enriched records include 6 crash reports, 2 fire reports, 3 injury reports, and 0 fatality reports. These fields come from complaint records and should be read in context.
Mileage clue
Mileage is available on 65 complaints, with an average reported failure mileage of 27,353 miles. Compare that with the mileage on the listing.
Questions to ask the seller
- Have you had any problems related to visibility/wiper, service brakes, unknown or other?
- Can I see recent maintenance and repair records?
- Has the vehicle ever been towed, involved in a crash, or repaired for the same issue twice?
- Can we also check the recall record for this 2022 Ford Bronco?
Used-car checklist
Use these complaints before the test drive.
Build a buyer checklist to turn these issues into questions and inspection points.
2022 Ford Bronco
Build buyer checklist Compare with other years Sends year, make, and model to pre-fill your checklist.
How severe are the 2022 Ford Bronco complaints?
6 Crash
2 Fire
3 Injury
0 Fatality
12 Towed
0 Medical attention
What are the most common 2022 Ford Bronco complaint categories?
VISIBILITY/WIPER 62
SERVICE BRAKES 24
UNKNOWN OR OTHER 20
ENGINE 19
SUSPENSION 18
POWER TRAIN 17
STRUCTURE 14
FUEL SYSTEM, GASOLINE 11
STEERING 11
VISIBILITY 10
345 total complaints on record
Latest complaints
| Date | Component | Summary | Severity | Mileage |
|---|---|---|---|---|
| Dec 2022 | VISIBILITY/WIPER | If windshield wipers are placed in normal or fast mode they start out fine, then get slower and slower until they stop completely. I needed to toggle between normal and fast just to keep them working. (I verified I’m NOT in interment mode). | Crash: No Fire: No | Unknown |
| Dec 2022 | VISIBILITY/WIPER | When the windshield wipers are set to normal operation (not intermittent), the wipers would slow down and sometimes stop completely after a few wipes. There is no a automatic wiper mode. This is a safety defect on a new car. The wipers would stop during heavy rain. It does not matter if the vehicle is moving or not. | Crash: No Fire: No | Unknown |
| Dec 2022 | VISIBILITY/WIPER | The windshield wiper will not stay on continuously. It malfunctions every time I have it on continuous low or high speed. I was driving in heavy rain with the windshield wiper on high continuous speed. After about 30 seconds it goes into intermittent mode, only cleaning the windshield every 3-4 seconds or so. It makes driving very difficult in the rain and dangerous as I cannot see the road. Same thing happens on the regular continuous speed setting. It is reproducible every time I use the wipers rain or shine. I checked on the Ford Bronco Forum website, and it is a common complaint. | Crash: No Fire: No | Unknown |
| Dec 2022 | UNKNOWN OR OTHER | There is an open recall on my vehicle for possible poor adhesion between the windshield and body (violation of federal motor vehicle safety standard FMVSS 212). I took my vehicle to a Ford dealership on 12/5/22 for this repair, as well as the repair other minor issues. I received a call on 12/7/22 from the dealership to inform me that they would not perform the recall fix due to the fact that my windshield has a crack across the middle and could possibly break during the removal. They said that I need to have the windshield replaced at my own cost, then bring it back in so that they can remove the new windshield and perform the recall fix. Nothing in the recall notification says that the windshield must be in "like new" condition in order to be eligible for the repair. | Crash: No Fire: No | Unknown |
| Dec 2022 | POWER TRAIN | The contact owns a 2022 Ford Bronco. The contact stated while driving approximately 5 MPH and attempting to shift the manual transmission from first to second gear, the transmission failed, and the clutch went to the floorboard. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer where it was diagnosed and determined that the clutch had burned, and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 4,500. | Crash: No Fire: No Towed | 4,500 |
| Dec 2022 | WHEELS,UNKNOWN OR OTHER | I am filing a complaint because as I was driving my new 2022 Ford Bronco Big Bend the front passenger wheel popped off. There was no previous warning signs to let me know something was wrong. It seems as though the bolts/ lug nuts just snapped as I was driving. The tire popped off rolled back hit the car causing it to bounce and then fall and drag for a bit before I was able to come to a full stop while the wheel rolled down the street. This caused a lot of damage to the car from body to suspension. Luckily I was traveling at low speeds so I was not injured and luckily no one else was near to be injured by the run away wheel. I had the car towed to AutoNation Ford in Katy where they and insurance representatives inspected it. AutoNation has had the car for over a month and they still have not fully repaired the vehicle. I do not fully understand what went wrong. | Crash: No Fire: No | Unknown |
| Dec 2022 | FUEL/PROPULSION SYSTEM | The vehicle started leaking fuel from under the passenger front fender. We were able to get the vehicle off of the highway. When I opened the hood it appeared that the leak was coming from the top area of the engine. The vehicle was towed to a Ford dealership and we are waiting for the reason it was leaking. This vehicle is a bit over 6 months old and has less than a thousand miles on it. I am aware that Ford has a recall on the Bronco Sport model but mine is a regular Bronco with the 2.7 liter engine. There were no warning lights or buzzers prior to this incident. | Crash: No Fire: No | Unknown |
| Dec 2022 | UNKNOWN OR OTHER | Inside above the rear seats is a metal bar and it’s invaded with plastic. At first the plastic where the screw is at cracked all around the bar in 2 places. Now the plastic is completely off of the bar . Ford is saying it’s normal wear and tear and it’s NOT… | Crash: No Fire: No | Unknown |
| Nov 2022 | ENGINE | The contact owns a 2022 Ford Bronco. The contact stated while starting the vehicle he heard a rattling nosing coming from the vehicle. There was no warning light illuminated. The contact stated that after the vehicle warmed up, the sound went away. The vehicle was taken to the dealer and the mechanic confirmed the abnormal sound coming from the vehicle, but no failure was found. The manufacturer was contacted and advised the contact to reach out to the NHTSA Hotline and file a complaint. The failure mileage was 12. | Crash: No Fire: No | 12 |
| Nov 2022 | SEAT BELTS | Front passenger seatbelt buckle will not engage the latch plate. Vehicle was inspected by dealer after customer complaint. Dealer informed customer that seatbelt buckles were all inspected and working normally. This issue is still occurring on intermittent basis. Was told by dealer that it would not "accept a video showing the problem." | Crash: No Fire: No | Unknown |
| Nov 2022 | POWER TRAIN,ENGINE | Bronco has less than 43 miles. Took vehicle on highway and went to go pass a semi and the vehicle lost all power. This could of caused a wreck if there was someone behind me trying to pass the semi as well. Took back to the Dealership and the turbo failed on my brand new Bronco. Please see Bronco6G for someone who is logging a list of other members that had similar issues. https://www.bronco6g.com/forum/threads/2-3-2-7-failed-turbo-list-7-counting-slowly-working-on-list.59162/ | Crash: No Fire: No | Unknown |
| Nov 2022 | ENGINE | Brand New Bronco Black Diamond Edition. Driven 1000 miles and now engine will not accelerate. Loud noises coming from engine with multiple warnings from the app: 1) powertrain / 4 wheel drive fault 2) transmission Control module / electrical fault with transmission sensor and it’s associated wiring 3)power train control module has detected one of the transmission speed sensors readings is operating outside of the expected range for the vehicle | Crash: No Fire: No | Unknown |
| Nov 2022 | POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE | Powertrain malfunction. Decreased power sent to powertrain. No turbocharge activation. Minimal acceleration, got up to only 45 on highway. Check engine light on, followed by Turbocharge wastegate malfunction. 6500 miles, 4 months old. 2.7L engine. Daily driver awaiting dealer service appointment. Not drivable. | Crash: No Fire: No | Unknown |
| Nov 2022 | ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE | Randomly the following takes place while vehicle is in motion at various speeds… Hill assist warning followed by (in rapid succession) pre collision assist not available, antilock brake fault Then the brakes momentarily give out then come back in non-powered mode which dangerously locks up the wheels when stopping System then resets itself Bronco6g forums have reported similar issues | Crash: No Fire: No | Unknown |
| Oct 2022 | UNKNOWN OR OTHER | We received a recall notice letter from our dealer, AutoNation Ford Bellevue, with instructions to call their service department. We cross checked our recall status by entering our vehicle's VIN on the NHTSA website's Recalls page and verified that there is indeed a recall associated with our vehicle. However, when we called the dealer, the dealer claimed that there is no recall for our vehicle in their system and refused to perform repairs. In our second attempt to contact the dealer, the service representative forwarded our information to an advisor, claiming that recalls with this campaign number must be scheduled by an advisor, but the advisor never called us back. | Crash: No Fire: No | Unknown |
| Oct 2022 | SERVICE BRAKES,ENGINE,FORWARD COLLISION AVOIDANCE | Vehicle reported Anti-Brake Fault. Vehicle reported Pre-Collision Fault. Vehicle reported 4 different hill start Assist Failures. I noticed the Pre-Collison feature did not work because the breaks never activated when there was a sudden merge into my lane going 65 miles per hour. The car says that the pre-collision feature is enabled but did not respond to a vehicle that came close to causing a wreck. | Crash: No Fire: No | Unknown |
| Oct 2022 | EXTERIOR LIGHTING | The contact owns a 2022 Ford Bronco. The contact stated while the vehicle was parked and not driven for more than 30 minutes, the headlights turned on independently. The contact stated that the failure had been intermittent however, the frequency of the failure had increased. The contact stated that the headlights warning light was illuminated. The contact stated that the four-position headlight dial could be rotated beyond the point where the markers on the dial indicated the level of lighting. The contact had not taken the vehicle to a local dealer. The vehicle had not been diagnosed and had not been repaired. The manufacturer had been informed of the failure. The contact researched online and related the failure to NHTSA ID Number: 10214159 (Exterior Lighting). The failure mileage was 2,177. | Crash: No Fire: No | 2,177 |
| Oct 2022 | ENGINE | Conducting the Bronco's 1st oil change at 5,003 miles at my home and the oil pan has missing or damaged pins/tabs that guide the oil plug out of and into the oil pan. When I turned the hand plug counter clockwise it did not ride out on the pans internal pins/tabs, it stayed fully seated and rotated fully to the stops. Was able to just just twist the the plug from stop to stop while fully inserted. Pulled the plug straight out and drained the oil. Once oil was drained tried feeling in the drain plug hole for any type of pin/tab that the plug is designed to guide in and out on and felt none. Did not see any damage to the plug. | Crash: No Fire: No | Unknown |
| Oct 2022 | ELECTRICAL SYSTEM,SERVICE BRAKES | The 2022 Bronco is listed as being able to be flat towed behind a motorhome and the software allows it to be put into flat tow mode. 49 states require that flat towed vehicles over a certain weight have supplemental braking. When the supplemental brake system is installed in a Bronco with the 2.7 liter engine it stops working correctly after 45 minutes because the electronic brake booster shuts off. This results in the supplemental braking system not having enough power to activate the brakes and can cause a serious accident because the motorhome cannot stop soon enough. Ford issued TSB 22-2210 to temporarily correct this issue but it simply disables the electronic brake booster (must remove fuses) and again leaves the towed vehicle with insufficient braking. Ford claims they are working a software update due out in September 2022, it is now mid October and no recall has been issued. | Crash: No Fire: No | Unknown |
| Oct 2022 | POWER TRAIN,ENGINE | The contact owns a 2022 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle made abnormally loud knocking sounds. The vehicle was towed to the dealer where it was diagnosed with metal shavings in the engine oil and filter. The dealer performed an oil change and informed the contact that the two transmission pumps and the engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 60. | Crash: No Fire: No Towed | 60 |
| Sep 2022 | ELECTRICAL SYSTEM,ENGINE | Engine/battery emitted smoke and sulfur odors. Causing concern of igniting or exploding | Crash: No Fire: No | Unknown |
| Sep 2022 | AIR BAGS | Upon delivery of my 2022 Ford Bronco Outer Banks from the dealer, I noticed the airbag case near roof on front passenger was cut/filed down to get the bolt secured on the end piece. The driver’s side is not installed in his manner. Upon questioning the dealership when I picked up my Bronco, I was told “You should be happy that you got your order! Don’t worry about an imperfection!!!!” I am attaching pictures of the front airbag cases on both sides. | Crash: No Fire: No | Unknown |
| Sep 2022 | UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM | In remote area in a canyon the engine quit suddenly due to fuel starvation caused by faulty fuel pump. The engine quit on the edge of the cliff and would not start again. Check Engine light was illuminated. After being towed to the nearest dealership. I was advised that my Bronco needs a new Fuel Pump. Vehicle warnings are as follows: - Electrical Fault with the Fuel Pump. - Engine Fuel Control System cannot achieve required fuel pressure to start engine. - Engine Fuel Control Sytem is unable to control fuel system pressure. | Crash: No Fire: No | Unknown |
| Aug 2022 | ELECTRICAL SYSTEM | Bronco base had no option for tow package but for $195 option 66C is a factory install auxiliary switches. Switch 1 is wired to 30 amps or 360 watts @12 v. This option has 2 parts. The second parts are not attached. Ford states the installer is liable, even though the factory supplies low wattage 16amp (1.5mm2) wires in various parts of the Bronco. When fasten to switch one at 360 watts (30 amps) the low wattage 16 AGW will heat and can cause a fire in the vehicle. The smell of the low wattage burning can be detected. Ford uses an old accessory wiring harness with a power module to supply wattage to a trailer for lights and braking. It was reported that when the trailer brake control module not installed by factory since option on certain model Broncos, the emergency braking module would be activate correctly and the sway controls had to disabled. Issues have been filed with Ford, but Ford has not responded on Bronco Base models. | Crash: No Fire: No | Unknown |
| Aug 2022 | ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE | Bronco MY 2022 Owners manual pages 288-289 on suv shows how to disengage in features menu the background ESC controls for yaw in the Trailer sway subsystem of ESC.When a dangerious highway sway of a trailer occurs, this subsystem will detect yaw and apply brakes.It is reported on F150 that rear brakes will heat up and may fail.Base Bronco, for marketing purposes cannot be factory equipped tow package options, but accessories market tow hitch and electric harness. Big Ben and others model may or may not have option. Cas38178902 was open and selling dealer has been advised. If brake start to heat up and seaze pads to rotors the Base Bronco has no method to disable the trailer sway controls since the MAP factory was instructed not to enable the trailer tow control. Jackknifing may occur on base Bronco with afterfactory tow equipment. | Crash: No Fire: No | Unknown |