Complaint volume
1134 consumer-submitted complaints are matched to this model year. Treat the count as a research signal, then read the actual summaries for repeated symptoms.
Complaint records
2020 Ford Explorer Complaints
1134 consumer-submitted complaints on record for the 2020 Ford Explorer, grouped by component category.
1134 Total complaints
33 Crash reports
10 Fire reports
27 Injury reports
Complaint data reflects consumer-submitted reports. A complaint is not proof
of a defect, recall, or manufacturer fault. Enriched severity fields come
from official bulk records when the complaint can be matched by ODI number.
Buyer interpretation
How to use these complaints before buying
Complaint records are most useful when they turn into inspection points, seller questions, and comparison checks against nearby model years.
Pattern to inspect
The most common categories are power train, unknown or other, back over prevention. Use those categories as a test-drive checklist instead of judging the vehicle from the total count alone.
Severity flags
Enriched records include 33 crash reports, 10 fire reports, 27 injury reports, and 0 fatality reports. These fields come from complaint records and should be read in context.
Mileage clue
Mileage is available on 385 complaints, with an average reported failure mileage of 33,892 miles. Compare that with the mileage on the listing.
Questions to ask the seller
- Have you had any problems related to power train, unknown or other, back over prevention?
- Can I see recent maintenance and repair records?
- Has the vehicle ever been towed, involved in a crash, or repaired for the same issue twice?
- Can we also check the recall record for this 2020 Ford Explorer?
Used-car checklist
Use these complaints before the test drive.
Build a buyer checklist to turn these issues into questions and inspection points.
2020 Ford Explorer
Build buyer checklist Compare with other years Sends year, make, and model to pre-fill your checklist.
How severe are the 2020 Ford Explorer complaints?
33 Crash
10 Fire
27 Injury
0 Fatality
40 Towed
8 Medical attention
What are the most common 2020 Ford Explorer complaint categories?
POWER TRAIN 306
UNKNOWN OR OTHER 117
BACK OVER PREVENTION 56
ELECTRICAL SYSTEM 44
ENGINE 42
EXTERIOR LIGHTING 40
SERVICE BRAKES 27
VISIBILITY/WIPER 27
STRUCTURE 26
SEATS 25
1,134 total complaints on record
Latest complaints
| Date | Component | Summary | Severity | Mileage |
|---|---|---|---|---|
| Apr 2026 | POWER TRAIN | this vehicle has sustained a complete transmission failure at 117,000 miles. There are known issues with this 10 speed transmission that the automaker needs to own to and address. This poses a safety risk when traveling and there were no apparent signals of anything prior to this. The vehicle is a garage to have a new transmission installed and had to get a rental car to continue to work and will cost thousands of dollars out of pocket as a result of this issue. | Crash: No Fire: No | Unknown |
| Apr 2026 | POWER TRAIN | The failure involves the automatic transmission system (10-speed 10R60) in my Ford Explorer 2020. The issue appears to be internal, affecting clutch packs and/or internal components (spring-related failure was initially noted by the dealership).Yes, the vehicle and transmission are available for inspection upon request. The transmission malfunction caused delayed engagement and loss of proper power delivery, which created unsafe driving conditions. There were moments where the vehicle hesitated or failed to respond properly when accelerating, increasing the risk of being struck in traffic or being unable to move out of the way of oncoming vehicles. This presents a clear safety concern, especially in traffic or intersections. Yes, the issue was inspected and confirmed by an authorized Ford dealership. The dealership initially diagnosed the problem as an internal transmission failure involving clutch-related components. However, those diagnostic notes were later removed or altered in the service record. I have retained screenshots of the original diagnosis as evidence. The vehicle has been inspected by an authorized dealership representing Ford Motor Company. At this time, it has not been inspected by police or insurance representatives. The manufacturer has not physically inspected the vehicle but has reviewed the case and offered partial financial assistance. Yes. Prior to the failure, the vehicle experienced symptoms including harsh shifting, delayed engagement when shifting into drive or reverse, and abnormal transmission behavior. These symptoms developed over time before the failure occurred. In some cases, there were no warning lights present before the issue became severe, which made the failure more sudden and unexpected. I was informed the original technician is no longer employed and there is no service manager currently overseeing the department. This lack of oversight makes it difficult to verify the original diagnosis or changes made to service records. | Crash: No Fire: No | Unknown |
| Apr 2026 | STRUCTURE | The A-pillar trim on the driver's side is pulling away from the body of the car. The previous generation of this vehicle had the same issue and has had a recall. The trim can fly off while driving causing damage to other cars and accidents. The dealership body shop inspected the part and said that it needed replaced. I first noticed this due to the sound of wind while driving even with the windows shut. Not long after, I noticed the trim sticking out away from the body of the car. | Crash: No Fire: No | Unknown |
| Apr 2026 | PARKING BRAKE,POWER TRAIN | The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. While attempting to accelerate, the vehicle failed to respond as needed. The contact stated that after pulling over, an unknown warning light illuminated. Additionally, while depressing the brake pedal, the message to activate the electronic parking brake was displayed due to a critical fault within the shift lever and parking system. The vehicle was taken to a dealer, but it was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 124,000. | Crash: No Fire: No | 124,000 |
| Apr 2026 | POWER TRAIN | I was driving the vehicle through a neighborhood and there was a clunk noise and it sounded like my brakes were metal on metal. I stopped to ensure my brakes were okay. Then I continued to drive home when there was a louder clunk and the reared on my vehicle locked up and the car would no longer move. The reared differential unit had failed and exploded parts and put holes in the unit causing fluid to exit onto the street and lock up the drive tires. The vehicle was stranded in the middle of the street and could not move. There was no warning or indication of a failure. The vehicle was towed to the dealer and components were replaced under extended warranty. | Crash: No Fire: No | Unknown |
| Apr 2026 | ELECTRICAL SYSTEM | The contact owns a 2020 Ford Explorer. The contact stated that while driving approximately 65 MPH, the vehicle lost automotive power and stalled. The contact stated that there was an abnormal whining sound coming from the vehicle prior to the vehicle stalling. The vehicle was stopped and there was an abnormal burning rubber odor inside the cabin of the vehicle. The contact stated that the messages “Charging System Fault” and “Service Steering” were displayed. The contact stated that unknown warning lights were illuminated. The vehicle was towed to the residence. The contact stated that her husband replaced the battery and the alternator, however the failure persisted, and the vehicle was losing automotive power. The vehicle had not been taken to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 19V687000 (Electrical System). The manufacturer was informed of the failure, and the contact was informed that the VIN was not included in the recall. The failure mileage was 113,849. | Crash: No Fire: No Towed | 113,849 |
| Apr 2026 | POWER TRAIN | I am filing a safety complaint regarding my 2020 Ford Explorer (2.3L engine) experiencing a transmission-related failure. At approximately 112,000 miles, the vehicle began exhibiting a dangerous failure pattern. While braking, a loud mechanical noise occurs, followed by hesitation and inability to properly accelerate. The vehicle then displays a “Shift System Fault” warning. After this occurs, the vehicle struggles to respond when attempting to accelerate, creating a serious safety hazard, especially when merging into traffic or crossing intersections. This issue appears to be consistent with Ford Technical Service Bulletin 23-2249, indicating the manufacturer is aware of a defect involving the transmission system. Despite this, no recall has been issued, and I have been quoted a significant out-of-pocket repair cost. The sudden loss of acceleration and erratic shifting presents a clear safety risk that could lead to a crash. I am requesting that this issue be investigated for a potential recall due to the safety implications. | Crash: No Fire: No | Unknown |
| Apr 2026 | POWER TRAIN | Vehicle stuck in park. But will go in gear but just won’t move. | Crash: No Fire: No | Unknown |
| Apr 2026 | AIR BAGS,SEATS,UNKNOWN OR OTHER | On my 2020 Explorer ST, the plastic backing on the front seats is popping off and exposing the seats airbags. My dealer said ONE replacement backing would be $1400 to replace. In a facebook group I am in, multiple people have complained on the 2020 ST that theirs has done the same thing. | Crash: No Fire: No | Unknown |
| Apr 2026 | ENGINE | My vehicle is experiencing manufacturers defect identical to Ford program 21B35, yet Ford tells me my VIN is not covered under this program. Manufacturer defect includes car converter welds breaking, causing exhaust fumes to enter the cabin. This is a serious safety concern. | Crash: No Fire: No | Unknown |
| Apr 2026 | SUSPENSION,POWER TRAIN | Vehicle suffered a catastrophic drivetrain lock-up while traveling at approximately 25 mph. The rear wheels physically halted, creating an immediate loss of control and safety hazard. Upon inspection, the Rear Drive Unit (RDU) was found to have a failed pinion bearing/internal gear failure, resulting in dual fluid leaks. This is a REMEDY FAILURE related to Safety Recall 23S55 (NHTSA Campaign #23V675000). The vehicle underwent the 23S55 recall repair 90 days prior (Jan 2026). The internal failure is a direct consequence of latent fatigue and stress placed on the RDU pinion and housing due to the defective axle mounting bolts and subframe bushings addressed in the recall. Furthermore, the vehicle is within the coverage window of Ford Customer Satisfaction Program 24N01 (10-year/150,000-mile extension for Rear Axle Bolt and Housing). The dealer (Hertrich Ford) and Ford Corporate Case Management (ASO Case #XXX) have refused to authorize an Administrative Rental or acknowledge the related damage, leaving the owner in a hazardous financial and logistical situation. I am reporting this as a failure of the federal safety remedy to adequately protect the vehicle’s drivetrain from consequential damage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) | Crash: No Fire: No | Unknown |
| Apr 2026 | POWER TRAIN,SERVICE BRAKES,ENGINE | front end axle actuator failing and causing all safety systems to turn off, loss of power and can lead to seized up front end | Crash: No Fire: No | Unknown |
| Apr 2026 | UNKNOWN OR OTHER | Sunscreen failure on panoramic roof. At approximately 55,000 miles on car the sunscreen stopped going back in correctly, with very little use. Now it falls down into the backseat and blocks the view of the rear window of the car if opened. It’s a huge safety risk and now I can’t even use this feature Of my car due to failure of the clips on the screen which is way too expensive to repair and should not have to repair on a car this new with only 80,000 miles on it. | Crash: No Fire: No | Unknown |
| Apr 2026 | ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE | Three alerts appeared on my dash after starting my car. These alerts are “Pre-Collision Assist Not Available,” “Service AdvanceTrac,” and “4WD Fault Service Required.” This has been an ongoing issue with this vehicle which directly affects the safety of drivers. After discussing with other consumers, this system failure is happening more and more. While these alerts are displayed, the front end collision assist is completely nonfunctional, thus increasing the risk of an accident. The Advanced Traction Control System is also nonfunctional. Based on other consumers with the same experience, the only solution is to replace the AWD module. | Crash: No Fire: No | Unknown |
| Apr 2026 | POWER TRAIN | On Tuesday April 7 as I was driving to work, as I was stepping on the break to pull into the parking lot and when the car hit 25 mph it jerked forward.; this was the first time I’ve ever experienced this so I didn’t think much of it. When I was leaving work that evening pulling out of the parking lot onto the main street the car jerked forward once I hit hit 35 miles an hour and then again jerking as I was slowing down to 25 to make the stop at a light this happened five or six times I live 3.9 miles away from my job. This had never happened before. I called the Ford dealership in Brentwood, Ca Bill Brant Ford as I had an oil change scheduled for Friday, April 10. They told me they would check it out at the time of my appointment. I got a call from the service department saying that my transmission was shot and then I would have to buy a new one for $8000. My car is a 2020. It has 53,000 miles on it and I need to buy a new transmission? I’ve had cars for over 10 years that had never needed a new transmission!! There was never a maintenance light or a check light, so who knows how long this was going on and I wasn’t aware and now five days after the first experience I have to replace the transmission. The service department says it is an internal issue that is why I was not seeing any warning lights… so the owner does get to know there is a problem until it’s too late far a repair?? This does not sound like something that can happen in 5 days. | Crash: No Fire: No | Unknown |
| Apr 2026 | UNKNOWN OR OTHER | Scenic sunroof shade has drooped and sagged down impeding my visibility in the rear view mirror to check traffic while backing out and seeing my grandchildren in their car seats | Crash: No Fire: No | Unknown |
| Apr 2026 | EXTERIOR LIGHTING | The driver side headlight low beam will not work. Dealership said 1700 labor to replace. I have looked into this and several other ford explorer platinum owners have same issue. | Crash: No Fire: No | Unknown |
| Apr 2026 | POWER TRAIN | Thank you for your time reviewing my complaint. I've answered each of your bullet points below. - the transmission is hard shifting in low gears however no warning/no dashboard lights to indicate issue. The vehicle is available for inspection upon request. - I use my car for work which includes transporting individuals to work and appointments. This hard shift happened with a passenger while on the freeway in traffic, then continued for the remainder of the ride each time I approached low speeds. - A vehicle diagnostic was performed by an independent service center/certified mechanic and no errors registered with the transmission. However the transmission diagnosis was determined by the service center driving the car and experiencing the hard shifts. I have a copy of the report. - The vehicle or component has not been inspected by the manufacturer, police, insurance or any other representatives. _ There were no warning lamp messages leading to the problem or a this current time and currently there are no warning lights indicating the transmission issue, although it has been diagnosed by a certified mechanic/service center as "Engine concern - neutralizing in gears between 1st & 2nd". There were sporadic episodes of this "hard shifting" within the last few months and the frequency of hard stops occurring were random. Additionally, there were no warning lamps or messages to indicate an issue. On 4/4/26 a hard shift happened on the freeway and has been consistent daily at low speeds. | Crash: No Fire: No | Unknown |
| Apr 2026 | VISIBILITY/WIPER | I had a really disappointing experience at Delta Sonic Car Wash in [XXX] and feel like other customers should be aware. During my visit, an employee used a pressure washer on my windshield before I entered the wash. This caused small debris to stick to the glass, and instead of being removed, it stayed on my windshield as my car went through the wash. The equipment then dragged that debris across the glass, leaving a deep scratch about 8 inches long. My windshield was only 2 months old and in perfect condition before this. I reported the damage immediately on-site, but my claim was denied. There was no real accountability, no effort to make it right—just a flat refusal. What makes this even more frustrating is that my fiancé and I have been loyal customers for years. We’ve spent hundreds here and have had memberships every winter since 2018. Because of how this was handled, we have now canceled our membership and have urged others to do the same. Also worth noting—many of the reviews here focus heavily on the food and not the car wash itself, which I now find misleading based on my experience. I understand that accidents can happen, but how a business handles those situations matters. In this case, the damage was caused by their process, and they still chose not to take responsibility. I would recommend taking photos of your vehicle before entering or reconsidering using this location altogether. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) | Crash: No Fire: No | Unknown |
| Mar 2026 | VISIBILITY/WIPER | Sunroof liner is sagging, blocking rear vision. Currently unable to use sunroof unless I pay 4k for repairs. | Crash: No Fire: No | Unknown |
| Mar 2026 | UNKNOWN OR OTHER | The chrome overlay on the driver side interior door handle is chipping and caused an injury to my finger. The chipped chrome broke off and became wedged in my skin and also resulted in a 0.5in scratch. The injury was extremely painful and required medical attention to remove the broken chrome chip that was lodged in my finger. | Crash: No Fire: No | Unknown |
| Mar 2026 | POWER TRAIN,VEHICLE SPEED CONTROL | Since purchase as a preowned vehicle, we noted this vehicle is equipped with a faulty transmission/tcm software design that is dangerously unpredictable and creates erratic driving conditions. This passenger SUV Is equipped with a 10 speed automatic that (once at operating temperature) the gear shifts and operation become highly unpredictable, often causing severe safety issues navigating in traffic, slowing down to sudden stops, and any acceleration, frequently getting stuck in 1st gear or neutral while attempting to accelerate on roadways from a stop. The (10r60E) has nearly caused several accidents severe accidents while under normal use as our primary family vehicle. The Ford dealerships I contacted were aware the problem was concurrent on every vehicle equipped with that Transmission and deemed it normal operation. This is highly concerning there hasn’t been some sort of safety recall implemented as it is a known flaw that creates very unsafe driving conditions on a vehicle marketed to families. | Crash: No Fire: No | Unknown |
| Mar 2026 | POWER TRAIN | Vehicle Issue Description – 2020 Ford Explorer Limited (Transmission Failure) The issue involves the transmission system in a 2020 Ford Explorer Limited. The transmission began exhibiting hard and erratic shifting, particularly between lower gears and when decelerating to a stop. A within days experienced complete failure, leaving the vehicle unable to properly move or engage gears. There were no warning lights, messages, or dashboard indicators at any point prior to the failure. This lack of warning prevented any opportunity to address the issue before it became severe. This failure created a significant safety risk, as the vehicle became unreliable in traffic conditions. Hard shifting and delayed engagement made it difficult to predict acceleration and deceleration, increasing the risk of being rear-ended or unable to safely merge into traffic. The final failure rendered the vehicle inoperable, which could have been dangerous if it occurred in a high-traffic or unsafe location. The problem appears consistent with known transmission issues reported by other owners of 2020 Ford Explorers, including hard shifting, jerking, hesitation between gears, and sudden loss of drivability.  Many drivers report similar symptoms progressing to severe transmission problems or complete failure. At this time: •Confirmation by dealer or service center: 3/18/26 Despite the number of similar complaints and documented issues, there has not been a specific recall issued for the transmission system itself, although other drivetrain-related recalls (such as rear axle or driveline failures) have been issued for this model year.  Based on the pattern of symptoms and widespread reports, this appears to be a systemic issue affecting the transmission in this model year, rather than an isolated incident. | Crash: No Fire: No | Unknown |
| Mar 2026 | ELECTRICAL SYSTEM,SERVICE BRAKES | I previously reported a safety issue re. Brakes not working in park. Vehicle rolled back and car almost hit mom and young daughter walking behind vehicle in parking lot. When I brought it to BellFord in [XXX] they told me it was not covered under the recall since it wasn’t being caused by rear axle. Instead they wanted to charge me $3,000 to diagnose their manufacturing defect. In addition when I notified Ford rep who never said anything other then I must get car diagnosed and pay for it and then “we will see .” Ford complaint XXX and I believe this is the NHTSA Complaint # XXX. Here is my initial Ford complaint Cxh-XXX was closed without explanation no one could tell me why no one had contacted me. I am very concerned that Ford is not taking responsibility for defective cars. My car now has only 47k. Brake issue. I had to replace front boots due to leaking and front axle was leaking. I had that fixed and now rear back up camera isn’t working. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) | Crash: No Fire: No | Unknown |
| Mar 2026 | UNKNOWN OR OTHER | The driver side door latch is defective. I’ve often been locked in or out of my vehicle. Obviously the main door on the vehicle. Many times i have to climb over the center console to exit my vehicle. What if I’m in an accident or my car catches fire, I can’t get out. Leaving me trapped. Or if I’m in danger and need to get in my car but I’m locked out. Often since latch doesn’t function it doesn’t shut my automatic lights off potentially wearing down the battery. Pretty sure my insurance company would not be happy that they are insuring a vehicle with these dangers and potential for someone to enter my vehicle when it decides to not lock. I’ve been told the vehicle is not part of a recall and the vehicle part is on a national backorder with no ETA. Dealership contacted me recently stating part was in, lost a whole day of work to find out they ordered the wrong part and the part is still not available. I bought this vehicle used off of a lease program only a year ago with 42,000 miles and have only put less that 10,000 miles on it. Transmission issues but dealership says they can’t find anything wrong. Car jerks and makes wining grinding noises when first taking off. I find it hard to believe ford does not think this is s safety issue with driver being trapped in or locked out of vehicle. | Crash: No Fire: No | Unknown |